Routine maintenance specifics for low voltage rail electric transfer car companies

To keep your vehicle in good technical condition, prevent accidents and early damage, and increase its service life, perform careful maintenance on the following components of the entire vehicle.

After using the vehicle every day, even if the mileage is short, it must be charged to ensure the service life of the battery. Check the electrolyte level of one-third of the battery, and if it is close to the lower level, add the replenishment liquid in time, and continue charging for 1 hour after replenishment, so that the internal electrolyte is even and consistent.

 After charging, the electrolyte concentration is 1.280±0.005(25 degrees Celsius), if there is any deviation, adjust with distilled water, and finish charging for one hour. The vehicle driving process found that the voltmeter down to 60V need to be charged in time, otherwise will greatly reduce the service life of the battery.

 Low-voltage rail electric transfer car company said the connection point must be well connected, connected firmly to avoid burning the battery pile head. Keep the battery clean and dry, the air vent on the battery cover must not be blocked to avoid battery explosion. Battery surfaces such as electrolytes must be applied clean, to prevent leakage, rinse to prevent water into the battery, causing early damage to the battery. When the vehicle is out of use, it should be fully charged and stored, and replenish the electricity once a month. During the use of the battery, the battery should be charged once a month with a balanced charge of 24 hours each time.

When charging the charger, connect the battery first and then connect the power supply, otherwise, the charger will be burned. Forbid the charger to get wet in the rain. The charger can automatically complete charging according to the battery's ability to accept, no need to open the battery cover, will not be a strong charge, overcharge. When charging, you should pay attention to the indicator light, if it can't charge normally, you should notify our company for maintenance.

The low voltage rail electric transfer car company strictly prohibits water in the control system, otherwise, it will burn out the controller. Keep the controller surface clean for heat dissipation. Keep a good connection between controller, battery and accelerator. The Brake system by adjusting the position of the limit bolt is the travel between pedals is 10-15mm.

The brakes become less effective is that the brake system should be checked for damage.